| 谭超，李俊杰，赵福明.油瓜种仁油提取工艺及理化成分分析[J].中国油脂,2017,42(02):.[TAN Chao，LI Junjie，ZHAO Fuming.Extraction process and analysis of physicochemical composition of kernel oil from Hodgsonia macrocarpa (Bl.)Cogn.[J].China Oils and Fats,2017,42(02):.] |
| 油瓜种仁油提取工艺及理化成分分析 |
| Extraction process and analysis of physicochemical composition of kernel oil from Hodgsonia macrocarpa (Bl.)Cogn. |
| |
| DOI： |
| 中文关键词: 油瓜 种仁油 提取工艺 理化分析 |
| 英文关键词:Hodgsonia macrocarpa (Bl.)Cogn. kernel oil extraction process physicochemical analysis |
| 基金项目: |
|
| 摘要点击次数: 980 |
| 全文下载次数: 0 |
| 中文摘要: |
| 以油瓜种仁为原料，采用单因素实验研究不同提取剂、提取时间、提取温度、料液比对油瓜种仁油得率的影响，并进行正交实验。结果表明:最佳提取条件为正己烷作提取剂、提取时间190 min、提取温度90?℃、料液比1∶?80，在此条件下，油瓜种仁油得率为60.02%。所提油瓜种仁油相对密度090±0.05，酸值(KOH)(11.21±0.13 )mg/g；钾、锌、铁、锰、镁、钙、铜含量分别为940、115、221、0.262、124、504、0.286 mg/kg，磷、钠含量分别为0.189%、0.106%，铅含量为0.042 mg/kg，未检测出黄曲霉毒素B1。油瓜种仁油由9种脂肪酸组成，以亚油酸(45.96%)、棕榈酸(29.90%)、油酸(14.16%)和硬脂酸(8.48%)为主，单不饱和脂肪酸(MUFA)含量与多不饱和脂肪酸(PUFA)、饱和脂肪酸(SFA)含量的比为1∶?3.3∶?2.7，n-6 PUFAs含量与n-3 PUFAs含量的比为63∶?1。 |
| 英文摘要: |
| With Hodgsonia macrocarpa （Bl.）Cogn. kernel as raw material, based on the single factor experiment, the effects of different extraction solvents, extraction time, extraction temperature and ratio of material to liquid on oil yield were studied by orthogonal experiment. The results showed that the optimal extraction conditions were obtained as follows: with n-hexane as extraction solvent, extraction time 190 min, extraction temperature 90?℃, and ratio of material to liquid 1∶?80. Under these conditions, the oil yield was 6002%. The relative density and acid value of the oil were 0.90±0.05 and (11.21±0.13) mgKOH/g respectively. The contents of K, Zn, Fe, Mn, Mg, Ca, Cu, P and Na were 940, 11.5, 22.1, 0.262, 124, 504, 0.286 mg/kg, 0.189% and 0.106% respectively. The Pb content was 0.042 mg/kg and aflatoxin B1was not detected. Hodgsonia macrocarpa (Bl.)Cogn. kernel oil contained nine kinds of fatty acids, and linoleic acid (45.96%), palmitic acid(29.90%), oleic acid(14.16%) and stearic acid(8.48%) were the main fatty acids. The ratio of monounsaturated fatty acid(MUFA) to polyunsaturated fatty acid(PUFA) to saturated fatty acid(SFA) was 1∶?3.3∶?2.7 and ratio of n-6 PUFAs to n-3PUFAs was 63∶?1。 |
| 查看全文 查看/发表评论 下载PDF阅读器 |
| 关闭 |
|
|
|
