| 汤须崇1，彭梦琪1，林雯青1，等.黄秋葵籽油的超临界CO2萃取 及其软胶囊制备工艺研究[J].中国油脂,2021,46(5):.[TANG Xuchong1, PENG Mengqi1, LIN Wenqing1,etc.Supercritical CO2 extraction of okra seed oil and preparation of its soft capsule[J].China Oils and Fats,2021,46(5):.] |
| 黄秋葵籽油的超临界CO2萃取 及其软胶囊制备工艺研究 |
| Supercritical CO2 extraction of okra seed oil and preparation of its soft capsule |
| |
| DOI： |
| 中文关键词: 黄秋葵籽油 超临界CO2萃取 软胶囊 制备 工艺优化 |
| 英文关键词:okra seed oil supercritical CO2 extraction soft capsule preparation process optimization |
| 基金项目: |
|
| 摘要点击次数: 720 |
| 全文下载次数: 463 |
| 中文摘要: |
| 以黄秋葵籽提油率为响应值，采用响应面法优化黄秋葵籽油超临界CO2萃取工艺；以崩解时限为评价指标，采用正交实验对黄秋葵籽油软胶囊制备工艺进行优化。结果表明：超临界CO2萃取黄秋葵籽油的最佳工艺条件为萃取压力30 MPa、萃取温度60?℃、萃取时间60 min，在此条件下提油率为17.23%；黄秋葵籽油软胶囊最佳制备工艺条件为水与明胶质量比1∶?1、明胶与甘油质量比3∶?1、溶胶温度80?℃、溶胶时间10 h，在此条件下黄秋葵籽油软胶囊的崩解时限为30.3 min，符合《中国药典》中软胶囊崩解时限不大于1 h的要求。 |
| 英文摘要: |
| Taking the oil extraction rate of okra seed as the response value, the response surface methodology was used to optimize the supercritical CO2 extraction process of okra seed oil.Taking the disintegration time as the evaluation index, the preparation of okra seed oil soft capsule was optimized by orthogonal experiment. Th results showed that the optimal supercritical CO2 extraction conditions of okra seed oil were obtained as follows: extraction pressure 30 MPa, extraction temperature 60?℃, extraction time 60 min, and under these conditions, the oil extraction rate was 17.23%. The optimal preparation process of okra seed oil soft capsule were obtained as follows: mass ratio of water to gelatin 1∶?1, mass ratio of gelatin to glycerin 3∶?1, sol temperature 80?℃, sol time 10 h, and under these conditions, the disintegration time of the okra seed oil soft capsule was 30.3 min,which met the requirement of disintegration time not longer than 1 h of soft capsule in Chinese Pharmacopoeia. |
| 查看全文 查看/发表评论 下载PDF阅读器 |
| 关闭 |
|
|
|
