| 陈一峰，范明明，冷炎，蒋平平，张萍波.Li掺杂CeO2固体碱催化甘油酯交换合成碳酸甘油酯[J].中国油脂,2023,48(3):.[CHEN Yifeng, FAN Mingming, LENG Yan, JIANG Pingping, ZHANG Pingbo.Synthesis of glycerol carbonate by transesterification of glycerol catalyzed by Li doped CeO2 solid base[J].China Oils and Fats,2023,48(3):.] |
| Li掺杂CeO2固体碱催化甘油酯交换合成碳酸甘油酯 |
| Synthesis of glycerol carbonate by transesterification of glycerol catalyzed by Li doped CeO2 solid base |
| |
| DOI： |
| 中文关键词: 甘油 碳酸甘油酯 酯交换 固体碱 Li CeO2 |
| 英文关键词:glycerol glycerol carbonate transesterification solid base Li CeO2 |
| 基金项目: |
|
| 摘要点击次数: 1660 |
| 全文下载次数: 1998 |
| 中文摘要: |
| 针对由甘油制备碳酸甘油酯的酯交换法中催化剂制备方法复杂、活性组分易流失等问题，采用一锅法制备了Li掺杂CeO2固体碱催化剂。对催化剂进行了X射线衍射(XRD)、扫描电镜（SEM）、透射电镜（TEM）、BET、X射线光电子能谱(XPS)、CO2程序升温脱附(CO2-TPD)等表征。以甘油转化率和碳酸甘油酯产率为指标，对催化剂进行了筛选，并采用单因素实验对甘油酯交换合成碳酸甘油酯的工艺条件进行了优化，同时考察了催化剂的重复使用性能。结果表明:Li与CeO2之间能够产生协同作用，Li的掺杂能够明显增加CeO2的中强碱活性位点；Li、Ce与柠檬酸物质的量比为0.3∶1∶1时，催化剂催化活性最好；甘油酯交换合成碳酸甘油酯的最优反应条件为反应温度100℃、反应时间2.0 h、催化剂用量为甘油质量的1%、甘油与碳酸二甲酯物质的量比1∶2，在此条件下甘油转化率为90.16%，碳酸甘油酯收率为90.04%；催化剂在重复使用5次后活性无明显下降。采用一锅法制备的Li掺杂CeO2固体碱催化剂具有良好的催化性能，可用于催化甘油酯交换合成碳酸甘油酯。 |
| 英文摘要: |
| Aiming at the problems of complex preparation method and easy loss of active components of catalyst in the transesterification method of preparing glycerol carbonate from glycerol, Li doped CeO2 solid base catalyst was prepared by one pot method. The catalyst was characterized by XRD, SEM, TEM, BET, XPS and CO2-TPD. With conversion rate of glycerol and yield of glycerol carbonate as indexes, the catalyst was screened and the conditions of transesterification of glycerol to prepare glycerol carbonate were optimized by single factor experiment. The reusability of the catalyst was investigated. The results showed that there was a synergistic effect between Li and CeO2, and Li doping could significantly increase the medium and strong base sites of CeO2.When molar ratio of Li, Ce and citric acid was 0.3∶1∶1, the catalyst had the best activity. The optimal reaction conditions were obtained as follows: reaction temperature 100℃, reaction time 2.0 h, catalyst dosage 1% of glycerol mass, and molar ratio of glycerol to dimethyl carbonate 1∶2. Under these conditions, the conversion rate of glycerol was 90.16% and the yield of glycerol carbonate was 90.04%, and the activity of the catalyst did not decrease significantly after reused for five times.Li doped CeO2 solid base catalyst prepared by one pot method has good catalytic performance, and can be used to catalyze synthesis of glyceryl carbonate by transesterification of glycerol. |
| 查看全文 查看/发表评论 下载PDF阅读器 |
| 关闭 |
|
|
|
