| 王菊华，陈玉保，杨顺平，等.响应面法优化小桐子油酸法脱胶预处理工艺[J].中国油脂,2019,44(2):.[WANG Juhua, CHEN Yubao, YANG Shunping,etc.Optimization of acid-assisted degumming pretreatment of Jatropha curcas oil by response surface methodology[J].China Oils and Fats,2019,44(2):.] |
| 响应面法优化小桐子油酸法脱胶预处理工艺 |
| Optimization of acid-assisted degumming pretreatment of Jatropha curcas oil by response surface methodology |
| |
| DOI： |
| 中文关键词: 小桐子油 预处理 脱胶 响应面法 航空煤油 |
| 英文关键词:Jatropha curcas oil pretreatment degumming response surface methodology aviation kerosene |
| 基金项目: |
|
| 摘要点击次数: 1108 |
| 全文下载次数: 0 |
| 中文摘要: |
| 用于制备航空煤油的植物油含大量的胶质（以磷脂为主），需对其进行脱胶预处理。采用酸法脱胶研究了柠檬酸添加量、脱胶温度、加水量、搅拌转速、活性炭添加量、乙醇胺（MEA）添加量和MEA反应时间对小桐子油脱胶效果的影响。在单因素实验基础上，根据Box-Behnken中心组合实验设计原理，用响应面法优化工艺条件。结果表明：最佳工艺条件为质量分数45%的柠檬酸添加量2.12%、MEA添加量0.52%、MEA反应时间26.23 min、搅拌转速258.47 r/min、脱胶温度50?℃、加水量2%、活性炭添加量2%，在此条件下，模型预测脱胶小桐子油磷含量为0.61 mg/kg，实测值为0.65 mg/kg，误差率为6.55%，证明模型可靠。 |
| 英文摘要: |
| The vegetable oil used for preparation of aviation kerosene contains a large amount of colloid (mainly phospholipid), which needs to be pretreated with degumming. By acid-assisted degumming, the effects of dosage of citric acid, degumming temperature, dosage of water, stirring speed, dosage of activated carbon, dosage of monoethanolamine (MEA) and MEA reaction time on degumming effect of Jatropha curcas oil were studied. On the basis of single factor experiment, the process conditions were optimized by response surface methodology according to Box-Behnken center combination experiment design principle. The results showed that the optimal process conditions were obtained as follows:dosage of 45% citric acid 2.12%, dosage of MEA 0.52%, MEA reaction time 26.23 min, stirring speed 25847 r/min, degumming temperature 50?℃, dosage of water 2% and dosage of activated carbon 2%. Under these conditions, the predictive value and measured value of the phosphorus content in the degummed oil were 0.61 mg/kg and 0.65 mg/kg respectively, and the error rate was 6.55%, which proved that the model was reliable. |
| 查看全文 查看/发表评论 下载PDF阅读器 |
| 关闭 |
|
|
|
