杨国龙,徐倩,胡培泓,刘伟,孟鹏程.蜂蜡基油凝胶中的晶型及结晶聚集体的结构层次[J].中国油脂,2023,48(2):.[YANG Guolong, XU Qian, HU Peihong, LIU Wei, MENG Pengcheng.Crystal form and structural hierarchy of the crystal aggregates in beeswax-based oleogels[J].China Oils and Fats,2023,48(2):.]
蜂蜡基油凝胶中的晶型及结晶聚集体的结构层次
Crystal form and structural hierarchy of the crystal aggregates in beeswax-based oleogels
  
DOI:
中文关键词:  蜂蜡基油凝胶  晶型  微观结构与形态  结构层次
英文关键词:beeswax-based oleogel  crystal form  microstructure and morphology  structural hierarchy
基金项目:
作者单位
杨国龙,徐倩,胡培泓,刘伟,孟鹏程 河南工业大学 粮油食品学院郑州 450001 
摘要点击次数: 746
全文下载次数: 242
中文摘要:
      为解释蜂蜡基油凝胶持油性较好的原因,对蜂蜡基油凝胶中的晶型及结晶聚集体的结构层次进行研究。分别以高油酸葵花籽油和大豆油为原料油,蜂蜡为凝胶因子制备蜂蜡基高油酸葵花籽油油凝胶和蜂蜡基大豆油油凝胶,采用X-射线衍射和偏光显微分析技术分别研究了2种蜂蜡基油凝胶的晶型与微观形态。X-射线衍射分析结果表明,蜂蜡基油凝胶在2θ为21.3°和23.7°处有明显衍射峰;但在小角区域没有明显的衍射峰。偏光显微分析结果表明,在放大倍数为500倍时,可观察到单个的细小针状物或棒状物(初级颗粒)及其聚集体(簇),还有由3个或4个这样的聚集体形成的更大的聚集体群(簇群),其形状呈十字花瓣状或海胆状,据此提出了蜂蜡基油凝胶结晶聚集体的结构层次,即初级颗粒-簇-簇群-网络结构,这种网络结构使油凝胶结晶聚集体的结构紧凑、比表面积大、颗粒细小,能很好地束缚油凝胶中的液体油,使得蜂蜡基油凝胶表现出很好的持油性。
英文摘要:
      To explain the reason for better oil-holding properties of beeswax-based oleogels, the crystal form and structural hierarchy of crystal aggregates in beeswax-based oleogels were investigated. The beeswax-based high oleic sunflower seed oil and soybean oil oleogels were prepared using high oleic sunflower seed oil and soybean oil as the raw oil and beeswax as the gel factor, respectively.The crystal form and microscopic morphology of beeswax-based high oleic sunflower seed oil and soybean oil oleogels were studied by X-ray diffraction and polarized light microscopy(PLM), respectively. The results of X-ray diffraction showed that the beeswax-based oleogels presented two distinct peak at 2θ 21.3°and 23.7°, however there were no distinct peak in small angel region. The results of PLM indicated that at a magnification of 500, single fine needles or rods (primary particles) and their aggregates (clusters) could be observed, as well as larger aggregate of clusters (clusters) formed by three or four such aggregates with a crossed petal or sea urchin shape. According to the PLM, the structural hierarchy of the crystal aggregates in beeswax-based oleogels was proposed as primary particle-cluster-aggregate of clusters-network, and the network structure results in the compact structure of the crystal aggregates of the oleogels, large specific surface area and fine particles, which could well bind the liquid oil in the oleogels and make the beeswax-based oleogels exhibit good oil-holding properties.
查看全文   查看/发表评论  下载PDF阅读器
关闭
《中国油脂》杂志社 官方网站
地址:西安市劳动路118号 邮编:710082
电话:029-88617441 88621360 88626849 传真:029-88625310
您是第9728767位访客  京ICP备09084417号